2012 NINJA 650R MANUAL PDF

View and Download Kawasaki Ninja service manual online. Ninja Motorcycle pdf manual download. Also for: Ninja abs, Er-6f, Er-6f abs. Visit Kawasaki Motor Corps., USA owners center for up to date service manuals, parts diagrams, ROK™ info, owner support, warranty info, Kawasaki Protection. Kawasaki NINJA R User Manual • Preparation • Kawasaki Motorcycles.

Author: Sagar Samusar
Country: Argentina
Language: English (Spanish)
Genre: Marketing
Published (Last): 10 July 2012
Pages: 264
PDF File Size: 8.21 Mb
ePub File Size: 20.13 Mb
ISBN: 684-2-93814-498-3
Downloads: 11098
Price: Free* [*Free Regsitration Required]
Uploader: Kasar

Battery 12 V 10 Ah 7. Fix the turn signal relay to the frame. Also, replace the steel plates if their teeth are damaged. Fix the starter relay to the ribs on the battery case.

Torque – Breather Mannual Bolts: Page of Go.

Kawasaki Ninja – Owner’s Manual – Pages – PDF

When the engine starts, the water pump turns and the coolant circulates. Starter Circuit Relay E: Apply molybdenum disulfide oil solution. Clutch Lever Free Play Inspection Avoid sharp bending, kinking, flattening or twisting. Run the radiator fan lead inside the frame. Main Fuse 30 A 6. Rear Brake Light Switch 6. Torque – Speed Sensor Bracket Bolts: Fix the rear brake light switch lead connector to the clamp on the swingarm bracket.

The headlight comes on after the starter button is released and stays on until the ignition switch is turned off.

  BUREAUCRATIE WEBERIENNE PDF

Run the reserve tank overflow hose through the clamp. Install a new element so that the screen side faces up- ward.

Service Code 51, 52 Stick Coil Circuit 1. Forcibly prying off the seal cap to add water is very dangerous. If not removed, the anticorrosive treat- ment applied to the brake disc surface will interfere with brake action, and an unsafe riding condition could result. Headlight Circuit Relay B: When this accumulation is suspected or observed, flush the cool- ing system. Fix the clamp to the bracket. Insufficient or incorrect electrolye will reduce battery performance and service life.

Clutch not 2021 Engine oil level too low Shift fork bent or seized Engine oil poor quality or incorrect Gear stuck on the shaft Gauge incorrect Air suction valve trouble Inspect and replace see chapter 5. Never touch a hot engine.

Download Owners Manuals

Battery cable making poor contact Load excessive e. Torque – Water Pump Cover Bolts: Drive Chain Slack — — — If there is continuity, the harness has a short circuit to ground, and it must be repaired or re- placed.

Therefore, it should be handled carefully, never struck sharply, as with a hammer, or allowed to fall on a hard surface. Clamp Hold the headlight lead as shown. Main Fuse 30 A 9. If there is any doubt as to the condition of the reeds, re- place the air suction valve as an assembly.

  ASTM E122-09 PDF

Motorcycle Kawasaki Ninja Service Manual pages. Battery 12 V 10 Ah 5. Engine Stop Switch 3. Read the electrolyte safety label and the follow- ing procedures carefully before battery activa- tion.

Engine Stop Switch Run the front wheel rotation sensor lead as shown. Remove the fuel tank see Fuel Tank Removal and check the fuel hose [A]. Road Clearance mm 5. Throttle Valve Dual throttle valve Bore 38 mm 1. Pull the bulb out to prevent damage to the bulb. Valve Seat Cutter Holder Bar: Run the main harness as follows; through the guide, on the left side of the head majual, inside the clamp on the bracket.

Sealed battery electrolyte has a higher concentration of sulfuric acid. It is meant simply as a rough guide to assist the troubleshooting for some of the more common difficulties in DFI system. Fix the ignition switch lead connector upper and the left switch housing lead connector lower to the bracket.

Frame Ground 1 3.